NEO QUICK START GUIDE
Step 1. Fit Rear Wheels
Both rear wheels are interchangeable and can be fitted to either side. Simply press and hold the centre release button on the wheel and guide the wheel carefully onto the axle shaft releasing the button when the wheel is fully inserted into the carts drive sprocket. To remove the rear wheels, depress the centre button on the wheel and slide the wheel off the axle shaft.
You will notice there are 2 positions for the rear wheels on the axle shaft. The wheels should be fully inserted on the axle shaft and engaged with the drive sprocket for normal powered drive, however in the event of a power/battery failure the wheels can be moved outwards to a second outer position on the axle shaft which allows the wheel to become disengaged from the drive sprocket and into a ‘freewheeling’ position.
Step 2. Open Frame
After fitting the rear wheels, undo the frame quick release locking strap located next to the battery tray.
Step 3. Front Wheel Assembly
Once the frame is opened fit the front wheel assembly by simply inserting the locating pins into the main frame. Insert the wheel assembly fully until the quick release catch is fully located. When removing the front wheel depress the release latch and whilst holding open pull out the front wheel assembly.
Step 4. - Scorecard Holder
Attach the holder by the magnetic connection next to the accessory station.
Step 5. Golf Bag
Fit your golf bag to the frame ensuring the base of your bag is located correctly onto the upper and lower bag supports. The NEO trolley accepts a loaded cart bag up to a recommended 18kgs weight. Attach the upper and lower silicon bag support straps and tension accordingly.
Step 6. Operating Instructions:
1. Place the battery in battery tray and connect power plug. Ensure the terminals are red to red and black to black.
2. To move forward simply press the thumb throttle control downwards. The cart has a soft start function that will allow the trolley to start moving forward slowly then automatically increase speed relative to the position of the thumb speed controller.
3. For long straight fairway runs you can utilise the Cruise feature so that both your hands remain free. This feature is a ’walk along’ option and you should always remain within arm’s length of the cart to regain manual control when needed. REMEMBER: Press cruise control button for 2 secs whilst maintaining desired speed to activate cruise function.
4. Always disconnect and remove battery when finished using the cart and prior to folding for storage.
Notes
Should your cart encounter an immovable obstacle whilst in use the NEO trolley has a circuit protection function that will shut off power to the motor when a current overload is detected.
Depending on the type and extent of current overload the system encounters it may take a short time for the cart to be able to resume normal operation as the electrical circuit may have to undergo a cool down procedure.
To reset simply press the cruise control button once and then operate the thumb control as normal.
Distributor/Retailer & Customer
Battery & Charger Guide
NOTE: Only use the approved WISHBONE™ Battery and Charger supplied. Failure to do so could damage components in the cart and invalidate your warranty.
__________________________________________________________________________________
The Wishbone battery is supplied partially charged, Once you receive your battery please put it on a full charge cycle within 90 days of receipt. A full charging cycle will take around 3-5 hours. Failure to do so could put the battery into a deep discharge state and unable to charge.
Connect the battery to the charger and then connect to your mains outlet. Whilst your battery is charging a red light will show on the charger, once the charge cycle is complete the green light will show.
Following a normal charge cycle your battery will remain fully charged for at least 3 months.
Your battery contains a sophisticated battery management system (BMS) that protects the cells from damage, prolongs cell life and maintains the cells to optimum levels within the parameters of the application.
Do’s and Don’ts
· Charge your battery as soon as possible after use but certainly within 24 hours of use. The most damaging aspect for any rechargeable battery is to leave it stored in a discharged condition.
· Once charged and the GREEN light is on, unplug charger from battery and mains.
· Only use the Wishbone supplied battery and charger.
· Never try to open the battery or charger, there are no user serviceable parts inside.
· Do not store in your car boot where temperatures can reach over 40 Celsius in summer.
· Always ensure your battery is fully charged before use.
If you experience any difficulties or have questions, please direct these to your retailer or distributor.